Hyster Diagnostic Trouble Codes Electrical System

Description

• Model List:
  • Diagnostic Trouble Codes

• 1. RM1112_TOSS 2 NO OUTPUT_2
• 2. RM0231-(01-2016)-US-EN
• 2.1. General
• 3. RM0231-(03-2020)-US-EN
• 3.1. General
• 4. RM1097-(03-2020)-US-EN
• 4.1. Series Code / Model Designation Reference Table
• 4.2. Description
• 4.3. Spark Plugs and Wires
• 4.4. Distributor Repair
• 4.5. Ignition Coil Replacement
• 4.6. Ignition Control Module Replacement
• 4.7. Starter Replacement
• 4.8. Sensors and Switches
• 4.9. Specifications and Special Tools
• 5. RM1097-(09-2015)-US-EN
• 5.1. Description
• 5.2. Spark Plugs and Wires
• 5.3. Distributor Repair
• 5.4. Ignition Coil Replacement
• 5.5. Ignition Control Module Replacement
• 5.6. Starter Replacement
• 5.7. Sensors and Switches
• 5.8. Specifications and Special Tools
• 6. RM1112-(10-2015)-US-EN
• 6.1. SECTION 9010 OPERATIONAL DIAGNOSTIC PROCEDURES
• 6.2. SECTION 9020 ENGINE
• 6.3. SECTION 9030 ELECTRICAL SYSTEM
• 6.4. SECTION 9040 DRIVE TRAIN
• 6.5. SECTION 9050 HYDRAULIC SYSTEMS
• 6.6. SECTION 9060 OPERATORS STATION
• 6.7. SECTION 9070 FRONT END (MAST) AND CHASSIS
• 6.8. SECTION 9080 SUPPLEMENTARY DATA
• 7. RM1112-(12-2019)-US-EN
• 7.1. SECTION 9010 Operational Diagnostic Procedures
• 7.2. SECTION 9020 Engine
• 7.3. SECTION 9030 Electrical System
• 7.4. SECTION 9040 Drive Train
• 7.5. SECTION 9050 Hydraulic Systems
• 7.6. SECTION 9060 Operators Station
• 7.7. SECTION 9070 Front End (Mast) and Chassis
• 7.8. SECTION 9080 Supplementary Data
• 8. RM1128-(01-2016)-US-EN
• 8.1. General
• 8.2. Deutsch Crimping Tool
• 8.3. Deutsch Connectors
• 8.4. Metri-Pack Connectors
• 8.5. Micro-Pack Connectors
• 8.6. Weather-Pack Connectors
• 8.7. AMPSEAL Crimping Tools
• 8.8. AMPSEAL Connector Assemblies
• 8.9. AMP Superseal 1.5 Crimping Tools
• 8.10. AMP Superseal 1.5 Connector Assemblies
• 8.11. AMP Fastin-Faston Hand Tools
• 8.12. AMP Fastin-Faston Receptacles and Housings
• 8.13. Wire Repair
• 8.14. Twisted/Shielded Cable and Leads Repair
• 8.15. Special Tools
• 9. RM1128-(03-2020)-US-EN
• 9.1. Series Code / Model Designation Reference Table
• 9.2. General
• 9.3. Deutsch Crimping Tool
• 9.4. Deutsch Connectors
• 9.5. Metri-Pack Connectors
• 9.6. Micro-Pack Connectors
• 9.7. Weather-Pack Connectors
• 9.8. AMPSEAL Crimping Tools
• 9.9. AMPSEAL Connector Assemblies
• 9.10. AMP Superseal 1.5 Crimping Tools
• 9.11. AMP Superseal 1.5 Connector Assemblies
• 9.12. AMP Fastin-Faston Hand Tools
• 9.13. AMP Fastin-Faston Receptacles and Housings
• 9.14. Wire Repair
• 9.15. Twisted/Shielded Cable and Leads Repair
• 9.16. Special Tools
• 10. RM1130-(03-2016)-US-EN
• 10.1. General
• 10.2. Menu Navigation
• 10.3. Main Menu
• 10.4. Passwords Menu
• 10.5. Password Administration
• 10.6. Other Password Functions
• 10.7. View Versions
• 10.8. Diagnostics
• 10.9. Set Travel and Braking
• 10.10. Setup Display Menu
• 10.11. Setup Hydraulics
• 10.12. Setup General Items
• 10.13. Operator Checklist
• 10.14. Calibrations
• 11. RM1130-(03-2020)-US-EN
• 11.1. General
• 11.2. Menu Navigation
• 11.3. Main Menu
• 11.4. Passwords Menu
• 11.5. Password Administration
• 11.6. Other Password Functions
• 11.7. View Versions
• 11.8. Diagnostics
• 11.9. Set Travel and Braking
• 11.10. Setup Display Menu
• 11.11. Setup Hydraulics
• 11.12. Setup General Items
• 11.13. Operator Checklist
• 11.14. Calibrations
• 12. RM1131-(03-2016)-US-EN
• 12.1. General
• 12.2. Menu Navigation
• 12.3. Main Menu
• 12.4. Passwords
• 12.5. Hourmeters
• 12.6. View Versions
• 12.7. Diagnostics
• 12.8. Set Travel and Braking
• 12.9. Setup Hydraulics
• 12.10. Setup Display
• 12.11. Setup General Items
• 12.12. Diesel Particulate Filter (DPF) Display
• 12.13. Diesel Particulate Filter (DPF) Display with Diesel Exhaust Fluid (DEF)
• 12.14. Calibrations
• 13. RM1131-(03-2020)-US-EN
• 13.1. General
• 13.2. Menu Navigation
• 13.3. Main Menu
• 13.4. Passwords
• 13.5. Hourmeters
• 13.6. View Versions
• 13.7. Diagnostics
• 13.8. Set Travel and Braking
• 13.9. Setup Hydraulics
• 13.10. Setup Display
• 13.11. Setup General Items
• 13.12. Diesel Particulate Filter (DPF) Display
• 13.13. Diesel Particulate Filter (DPF) Display 2-3.5T ICE Stage V
• 13.14. Diesel Particulate Filter (DPF) Display with Diesel Exhaust Fluid (DEF)
• 13.15. Calibrations
• 14. RM1134-(03-2020)-US-EN
• 14.1. Series Code / Model Designation Reference Table
• 14.2. Description
• 14.3. Proc_Cal_001 Service Password Entry
• 14.4. Proc_Cal_002 Hydraulic Valve Calibration Warm Up and Air Bleed
• 14.5. Proc_Cal_003 Save and Exit
• 14.6. Proc_Cal_004 Lift Valve Output Threshold
• 14.7. Proc_Cal_005 Lower Valve Output Threshold
• 14.8. Proc_Cal_006 Tilt Back Valve Output Threshold
• 14.9. Proc_Cal_007 Tilt Forward Valve Output Threshold
• 14.10. Proc_Cal_008 Aux 1 Dir A Valve Output Threshold
• 14.11. Proc_Cal_009 Aux 1 Dir B Valve Output Threshold
• 14.12. Proc_Cal_010 Aux 2 Dir A Valve Output Threshold
• 14.13. Proc_Cal_011 Aux 2 Dir B Valve Output Threshold
• 14.14. Proc_Cal_012 Aux 3 Dir A Valve Output Threshold
• 14.15. Proc_Cal_013 Aux 3 Dir B Valve Output Threshold
• 14.16. Proc_Cal_014 Load Weight Zero Point
• 14.17. Proc_Cal_015 Loaded Weight Calibration
• 14.18. Proc_Cal_016 Transmission Valve Calibration
• 14.19. Proc_Cal_016A Transmission Valve Calibration-Electronic Extended Function
• 14.20. Proc_Cal_016B Trans. Valve Calibration-Electronic and Electronic Extended Function
• 14.21. Proc_Cal_019 Mazda LP and Gas Accelerator Pedal Adjustment
• 14.22. Proc_Cal_025 Hydraulic Valve Pressure Gage Installation
• 14.23. Proc_Cal_026 Travel Speed Calibration
• 15. RM1134-(09-2015)-US-EN
• 15.1. Description
• 15.2. Proc_Cal_001 Service Password Entry
• 15.3. Proc_Cal_002 Hydraulic Valve Calibration Warm Up and Air Bleed
• 15.4. Proc_Cal_003 Save and Exit
• 15.5. Proc_Cal_004 Lift Valve Output Threshold
• 15.6. Proc_Cal_005 Lower Valve Output Threshold
• 15.7. Proc_Cal_006 Tilt Back Valve Output Threshold
• 15.8. Proc_Cal_007 Tilt Forward Valve Output Threshold
• 15.9. Proc_Cal_008 Aux 1 Dir A Valve Output Threshold
• 15.10. Proc_Cal_009 Aux 1 Dir B Valve Output Threshold
• 15.11. Proc_Cal_010 Aux 2 Dir A Valve Output Threshold
• 15.12. Proc_Cal_011 Aux 2 Dir B Valve Output Threshold
• 15.13. Proc_Cal_012 Aux 3 Dir A Valve Output Threshold
• 15.14. Proc_Cal_013 Aux 3 Dir B Valve Output Threshold
• 15.15. Proc_Cal_014 Load Weight Zero Point
• 15.16. Proc_Cal_015 Loaded Weight Calibration
• 15.17. Proc_Cal_016 Transmission Valve Calibration
• 15.18. Proc_Cal_016A Transmission Valve Calibration-Electronic Extended Function
• 15.19. Proc_Cal_016B Trans. Valve Calibration-Electronic and Electronic Extended Function
• 15.20. Proc_Cal_019 Mazda LP and Gas Accelerator Pedal Adjustment
• 15.21. Proc_Cal_025 Hydraulic Valve Pressure Gage Installation
• 15.22. Proc_Cal_026 Travel Speed Calibration
• 16. RM1246-(02-2018)-US-EN
• 16.1. General
• 16.2. Drive Axle Removal
• 16.3. Hub Seal Replacement
• 16.4. Planetary Reduction Repair
• 16.5. Brake Repair
• 16.6. Bevel Pinion
• 16.7. Differential Unit
• 16.8. Drive Axle Installation
• 16.9. Special Tools
• 16.10. Torque Specifications
• 17. RM1246-(04-2015)-US-EN
• 18. RM1247-(09-2018)-US-EN
• 18.1. General
• 18.2. Service Brakes Repair (Dry Brake)
• 18.3. Parking Brake Repair
• 18.4. Master Cylinder Repair
• 18.5. Accumulator
• 18.6. Modulating Brake Valve, Accumulator Charge Valve, and Accumulator
• 18.7. Service Brakes Adjustment (Dry Brake)
• 18.8. Brake System Air Removal
• 18.9. Brake Pedal Adjustment
• 18.10. Free Pedal Adjustment
• 18.11. Torque Specifications
• 19. RM1251-(09-2015)-US-EN
• 19.1. General
• 19.2. Engine Removal and Installation
• 19.3. Cylinder Head Repair
• 19.4. Engine Block Cleaning and Inspection
• 19.5. Piston Bore Preparation
• 19.6. Engine Mounts Installation
• 19.7. Lubrication System Repair
• 19.8. Timing Cover, Timing Sprockets, Camshaft, and Valve Lifters
• 19.9. Crankshaft Repair
• 19.10. Piston and Connecting Rod Assemblies Repair
• 19.11. Flywheel and Flywheel Housing Repair
• 19.12. Coolant Pump Repair
• 19.13. Thermostat Replacement
• 19.14. Starter Replacement
• 19.15. Fan Assembly Replacement
• 19.16. Drive Belt Installation
• 19.17. Compression Check
• 19.18. Engine Specifications
• 19.19. Torque Specifications
• 20. RM1250-(09-2018)-US-EN
• 20.1. Safety Procedures When Working Near Mast
• 20.2. Fork Replacement
• 20.3. Fixed Carriage Replacement
• 20.4. Integral Sideshift Carriage Repair
• 20.5. Hang On Sideshift Carriage Repair
• 20.6. Bolzoni Hang-On Sideshift Carriage Repair
• 20.7. Fork Positioner
• 20.8. Two-Stage Mast With Limited Free-Lift Repair
• 20.9. Two-Stage Mast With Full Free-Lift Repair
• 20.10. Three-Stage Mast With Full Free-Lift Repair
• 20.11. Mast Operation Check
• 20.12. Tilt Cylinder Adjustment
• 20.13. Lift Chains Adjustment
• 20.14. Mast Adjustments
• 20.15. Carriage Adjustments
• 21. RM1250-(11-2015)-US-EN
• 21.1. Safety Procedures When Working Near Mast
• 21.2. Fork Replacement
• 21.3. Carriage Replacement
• 21.4. Integral Sideshift Carriage Repair
• 21.5. Hang On Sideshift Carriage Repair
• 21.6. Two-Stage Mast With Limited Free-Lift Repair
• 21.7. Two-Stage Mast With Full Free-Lift Repair
• 21.8. Three-Stage Mast With Full Free-Lift Repair
• 21.9. Mast Operation Check
• 21.10. Tilt Cylinder Adjustment
• 21.11. Lift Chains Adjustment
• 21.12. Mast Adjustments
• 21.13. Carriage Adjustments
• 22. RM1556-(04-2018)-US-EN
• 22.1. General
• 22.2. LPG Tank and Bracket
• 22.3. Fuel Filter Unit
• 22.4. Throttle Body
• 22.5. Fuel Mixer with Direct Electronic Pressure Regulator (DEPR)
• 22.6. Control System
• 22.7. LP Converter
• 22.8. LPG Lock-Off
• 22.9. Exhaust System
• 22.10. LPG Fuel Testing
• 23. RM1556-(09-2015)-US-EN
• 23.1. General
• 23.2. LPG Tank and Bracket
• 23.3. Fuel Filter Unit
• 23.4. Throttle Body
• 23.5. Fuel Mixer with Direct Electronic Pressure Regulator (DEPR)
• 23.6. Control System
• 23.7. LP Converter
• 23.8. LPG Lock-Off
• 23.9. Exhaust System
• 24. RM1570-(03-2015)-US-EN
• 25. RM1557-(07-2019)-US-EN
• 25.1. General
• 25.2. Engine Removal and Installation
• 25.3. Cylinder Head Assembly Repair
• 25.4. Timing Gear Case and Timing Gears Repair
• 25.5. Drive Train, Camshaft, and Cylinder Block Repair
• 25.6. Lubrication System Repair
• 25.7. Fuel System Repair
• 25.8. Cooling System Repair
• 25.9. Flywheel and Flywheel Housing
• 25.10. Electrical Equipment Repair
• 25.11. Engine Specifications
• 25.12. Standard Torque Specifications
• 25.13. Special Torque Specifications
• 25.14. Special Tools
• 26. RM1557-(12-2015)-US-EN
• 26.1. General
• 26.2. Engine Removal and Installation
• 26.3. Cylinder Head Assembly Repair
• 26.4. Timing Gear Case and Timing Gears Repair
• 26.5. Drive Train, Camshaft, and Cylinder Block Repair
• 26.6. Lubrication System Repair
• 26.7. Fuel System Repair
• 26.8. Cooling System Repair
• 26.9. Flywheel and Flywheel Housing
• 26.10. Electrical Equipment Repair
• 26.11. Engine Specifications
• 26.12. Standard Torque Specifications
• 26.13. Special Torque Specifications
• 26.14. Special Tools
• 27. RM1569-(03-2015)-US-EN
• 28. RM1569-(11-2018)-US-EN
• 28.1. General
• 28.2. Charge Pump Repair
• 28.3. Torque Converter Replace
• 28.4. Housings and Chain Drive Repair
• 28.5. Clutch Packs Repair- 1 Speed Transmission
• 28.6. Clutch Packs Repair- 2 Speed Transmission
• 28.7. Control Valve Repair
• 28.8. MONOTROL Pedal Repair
• 28.9. Direction Control Lever
• 29. RM1579-(11-2019)-US-EN
• 29.1. General
• 29.2. Engine Removal and Installation
• 29.3. Cylinder Head Assembly Repair
• 29.4. Timing Gear Case and Timing Gears Repair
• 29.5. Drive Train, Camshaft, and Cylinder Block Repair
• 29.6. Lubrication System Repair
• 29.7. Fuel System Repair
• 29.8. Cooling System Repair
• 29.9. Flywheel and Flywheel Housing
• 29.10. Electrical Equipment Repair
• 29.11. Engine Specifications
• 29.12. Standard Torque Specifications
• 29.13. Special Torque Specifications
• 29.14. Special Tools
• 30. RM1579-(12-2015)-US-EN
• 30.1. General
• 30.2. Engine Removal and Installation
• 30.3. Cylinder Head Assembly Repair
• 30.4. Timing Gear Case and Timing Gears Repair
• 30.5. Drive Train, Camshaft, and Cylinder Block Repair
• 30.6. Lubrication System Repair
• 30.7. Fuel System Repair
• 30.8. Cooling System Repair
• 30.9. Flywheel and Flywheel Housing
• 30.10. Electrical Equipment Repair
• 30.11. Engine Specifications
• 30.12. Standard Torque Specifications
• 30.13. Special Torque Specifications
• 30.14. Special Tools
• 31. RM1582-(01-2019)-US-EN
• 31.1. General
• 31.2. Drive Axle Removal
• 31.3. Reduction Gear Assembly
• 31.4. Wet Disc Brake Repair